Can Am X3 Turbo RR (2020) 195 HP ECU Bench Power Flash

All our heavy tune development is performed on our engine dyno rather than a wheel dyno. We do this for two reasons; First, an engine dyno removes the CVT drive system from the tuning equation. The CVT will always try to keep the engine REVs at within a narrow RPM range during a power sweep whereas our engine dyno can sweep the entire operating range of the engine. Secondly, the engine dyno can hold RPM's at very specific values which allows us to tune those areas, throttle openings and load levels without the Continuously Variable Transmission (CVT) varying the load and RPM.

Tuning the engine outside of the CVT allows us to deliver a more refined tune and eliminates all of the variables (tire size, clutching, strap tension, etc) which result in the incredible spectrum of dyno figures published for this vehicle. For example, the stated dyno numbers for a bone stock 2020 X3 RR among our shop and others varied by over 20 WHP! All vehicles were tested on the same manufacturer dyno. This is ridiculous!

The factory rates the power of their engines at the crank and we do too. You can see from our dyno graphs that the power curves are extremely flat - in fact our tunes make within 6 horsepower of peak power over a 1200 rpm range! This means that even if your clutching is 500 or more RPMs off, your X3 will be sacrificing only a few ponies!

STOCK INJECTOR BENCH FLASH TUNES include tune file only 

BIG INJECTOR BENCH FLASH TUNES (STAGES 3Bi THROUGH STAGE 5) include tune file, X3 Turbo RR Big Injectors (set of 3), and Injector Adapter Harnesses (set of 3)

BIG INJECTOR BENCH FLASH STAGE 5x85 includes tune file, X3 High-Pressure Fuel Pump, X3 Turbo RR Big Injectors (set of 3), and Injector Adapter Harnesses (set of 3)

Big Injector Stage Tune Details:

For all Stage 4 Tunes and higher (22+ lbs of boost) we highly recommend our Plenum Reinforcement Brace or Torrent-F Intake Plenum

Stage 4 X100 and Stage 5 E85

Make 245 Crank HP!

These tunes are extremely potent and refined and do not need any additional hardware except for our EVP Big Injectors and Adapter HarnessesClutching highly recommended

Stage 5 X85

This tune is on an entirely different level - Making nearly 27 lbs of boost at sea level and 255 crank horsepower! That's about the same power level as our 2017-2019 Stage 6 Big Turbo kit!

Requires our direct replacement Fuel Pump Upgrade Kit and Plug-n-Play Wiring Harness Relay. The OEM fuel pump is a very low capacity, low pressure 155 liter per hour pump which is not capable of supplying enough fuel for the X85 upgrade at 27 lbs of boost. Our pump is a 265 liter per hour, high pressure pump that is used in our Big Turbo Systems.

Features:

• Revised intercooler fan settings - Makes the OEM intercooler far more effective!
• Left foot braking enabled for 2 foot operation
• Improved boost response / low to midrange power improvements
• Speed limits raised / TQ limits removed in Low & High Gear
• Low & High Gear rev limit increased from 8300 to 9000 RPMS
• Speed limiter raised
• Improved throttle response in all modes (E-Gas Settings Improved) - Linear throttle rather than the lazy pedal the factory has programmed
• Radiator cooling fan triggered sooner to keep coolant temperature in check on hot days and long pulls
• Race Start – No need to press the brake to start vehicle
• Fueling is corrected for the various stages so no fuel controllers are needed
• Wheel Dyno Tested - Engine Dyno Tested
• High Elevation Tested - Glamis / Dumont Extreme Heat Tested
• More Boost!
• Industry exclusive 2-Step Launch Control available!

NOTE: This Bench Flash Service requires removing and sending in your ECU to Kombustion's facility. Please print and fill out this ECU SUBMISSION FORM and submit it with your physical ECU. Customers are responsible for purchasing the shipping label and sending the ECU to Kombustion's facility. Return shipping of the ECU will be covered via UPS Expedited 2-day Delivery. (ECU Only, shipping for additional components not included.)

VEHICLE FITMENT

Can Am Maverick X3 195 HP TURBO RR (2020)